You are here


Company Information
ROCKLEDGE, FL 32955-5327
United States




# of Employees: 110

Ownership Information

HUBZone Owned: No

Socially and Economically Disadvantaged: No

Woman Owned: No

Success Stories

  1. SBIR-STTR-Success: Mainstream Engineering Corp.

    Stationing hungry soldiers in an Iraqi desert where temperatures can exceed 130 degrees Fahrenheit presents obvious logistical challenges. Refrigerating food is necessary but difficult, especially in remote locations. It’s also expensive and potentially dangerous to transport fuel to power the...
  2. SBIR-STTR Success: Mainstream Engineering

    Nearly thirty years ago, brand new Florida-based Mainstream Engineering received two small SBIR awards from the U.S. Air Force for the development of spacecraft heat rejection systems. But Dr. Robert P. Scaringe, President and Founder, already had transition on his mind long before that.“Taking a...

Award Charts

Award Listing

  1. Electrical Scavenging and Energy Regeneration for Improved Vehicle Efficiency

    Amount: $79,959.00

    Improvements in fuel efficiency for the developing ACV 1.1 vehicle are sought. While relatively efficient, even the best vehicle turbodiesel engines have efficiencies of only 30-44% depending on opera ...

    SBIRPhase I2017Department of Defense Navy
  2. Low Power, Rapid Detector of Trace Underwater Explosives

    Amount: $79,939.00

    The current state-of-the-art for an underwater unexploded ordnance (UUXO) detector is a single analyte sensor for detection of TNT, which only partially addresses the Navys requirement to detect the f ...

    SBIRPhase I2017Department of Defense Navy
  3. Metal-Encapsulated CNTs to Enhance Steel Wire Performance

    Amount: $229,198.00

    The Phase I proposal presented here details a procedure to produce metal encapsulated carbon nanotubes (CNTs) for integration into steel cabling for aircraft carrier arresting cables. The addition of ...

    SBIRPhase I2017Department of Defense Navy
  4. Power Electronic Based Active Current Balancing System

    Amount: $227,801.00

    Unbalanced loading of electrical generators can increase system losses, reduce generator lifetime, and increase the frequency of spurious circuit breaker tripping. Current technology to balance loads ...

    SBIRPhase I2017Department of Defense Navy
  5. Development of a novel heat transfer component for toroid inductor applications

    Amount: $229,353.00

    Matching circuit power inductor(s) (PI) applied between sonar senders and silicon-crystal-oscillator (SCO) reduce the sonar senders required output power by matching the senders output impedance to th ...

    SBIRPhase I2017Department of Defense Navy
  6. Predictive Models of Lead Acid Battery State of Charge and Health

    Amount: $99,824.00

    Lead acid batteries are the old commercially available rechargeable battery technology. They find application in a range of vehicle starting applications as well as a wide array of deep cycle uses suc ...

    SBIRPhase I2017Department of Defense Army
  7. Mobile and Efficient Sanitation System (MESS)

    Amount: $99,990.00

    Field Sanitation Centers (FSCs), a critical element of Army mobile kitchens provide a method to wash, rinse, and sanitize kitchen wares in order to conduct field feeding operations. Their primary func ...

    SBIRPhase I2017Department of Defense Army
  8. Four-Quadrant GaN-Based Battery Isolator Unit

    Amount: $994,761.56

    Military ground vehicles currently use two battery banks, one for powering loads and one for engine starting, connected together through battery-isolating diodes, which are heavy, inefficient, and fai ...

    SBIRPhase II2017Department of Defense Army
  9. Management of High Heat Fluxes Associated with LED IR Emitter Arrays

    Amount: $149,947.00

    Mainstream will develop a complete infrared emitter array package consisting of a hermetic housing, heat sink, power interconnect, and signal interface. For the initial phase, we will design, fabricat ...

    SBIRPhase I2017Department of Defense Air Force
  10. Demulsification and Purification System to Recover Contaminated JP-8

    Amount: $749,851.00

    Fuel is critical to any military operation. Preserving fuel that is stored and transported to the battlefield is critical to maintaining a high level of operational effectiveness. Fuel convoys and sto ...

    SBIRPhase II2017Department of Defense Air Force
US Flag An Official Website of the United States Government