Award Data

This Small Business Technology Transfer (STTR) Phase 1 project will lead to the development of a simple, cost effective technology which can recover helium from gas reservoirs containing helium concentrations too low to permit economic recovery at present. This will enable helium recovery from fields currently producing natural gas but considered uneconomical for the recovery of the contained heli ...

Ice crystals can form spontaneously from the freezing of water droplets at temperatures colder than -38

Higher operating temperature for the gas turbine engine is needed for enhanced efficiency, lower emission and increased performance goal. The current state-of-the-art thermal barrier coatings (TBCs) are not adequate to provide the needed protection for the metallic components of the turbine engine operating at higher TBC surface temperature (>1300

Currently the commercially available technologies for H2 separation such as pressure swing adsorption and cryogenic distillation are very energy intensive. Membrane technologies can be very energy efficient; but for high selective membranes low flux and high cost are the major challenges that frustrate commercialization. Recently, cermet has shown promise because of less precious metal usage and m ...

Hydrogen produced today from coal, natural gas, or biomass must be separated and purified outside the reactors using pressure swing absorption (PSA), a process that requires significant additional space and energy. Placing hydrogen-permeable membranes inside the reactors themselves would allow hydrogen to diffuse out, thereby reducing the cost of hydrogen production. In this Phase I effort, Mainst ...

This SBIR/STTR project delivers an ultra-low power structural health monitoring (SHM) system that uses autonomous, wirelessly embedded sensors to monitor and assess structural integrity in wind turbine blades. EASE features impedance-based active SHM, which is highly sensitive to damage like cracks, delimitations, mass variations, fastener failures and stiffness changes. Blades are the only wind t ...

Solid state lighting is being promoted as the ultimate lamps of future. Though the internal quantum efficiency of OLED devices is almost 100%, external efficiency is a mere 36% mainly because of poor light out-coupling (~40%) from the device. Improvement in light out-coupling to >70% and further reducing the manufacturing cost will rapidly accelerate the commercialization of the OLED technology. T ...

The fabrication of high-quality ultra thin (~20 micron) diamond crystals targets for 9 GeV highly polarized photon beams is an outstanding challenge. Current state of the art polishing/thinning techniques are not successful in thinning single crystal diamond to such dimension because of its extreme hardness and chemical inertness. These techniques create significant stresses surface and sub-surfac ...

Concern over CO2 emissions and global greenhouse effects has prompted new uses for reclaimed CO2 effluent from coal fired power plants. Similarly, volatile organic solvent emissions have prompted an initiative to identify cleaner solvents for high performance polymer processing, particularly when such processing requires large volumes of environmentally unfriendly, toxic organic solvents. Furthe ...

This DOE SBIR/STTR program will result in the commercialization of a low-cost anostructured composite thermoelectric device. Such devices represent the next generation solution for an increasingly strained energy market by converting existing waste heat into electrical power. More waste heat is generated by the combination of industry and automobiles than the total contribution of all renewable en ...